| | | |
|
|
|
|
|
05.28.08 - CSDX-39 - CHICAGO SANITARY DISTRICT DUMP CAR. THE CAR HAS A HANDBRAKE THAT HAS RUSTED AND IS INOPERABLE. - Kirk L. Warner (kwarner) Viewed: 3107 times.
|
05.31.08 - THE HANDBRAKE HAD THE FOUR RIVETS SECURING IT TORCHED OFF AND THE HANDBRAKE WAS REMOVED. - Kirk L. Warner (kwarner) Viewed: 3789 times.
|
06.01.08 - THE FIVE RIVETS THAT SECURE THE TWO HOUSING PARTS ARE BEING DRILLED OUT SO THAT THE HOUSING CAN BE REPAIRED. TO THE LEFT OF THE ELECTRIC DRILL, THE RUSTED OUT SECTION OF THE HOUSING IS VISIBLE. THE HANDBRAKE LOCK SHAFT, THE ROUND PART TO THE LOWER LEFT OF THE DRILL, HAS WORN THE HOUSING OUT. A BUSHING WAS CREATED AND WELDED INPLACE TO CORRECT THIS. THE SHAFT FOR THE GEAR TO THE RIGHT OF THE ELECTRIC DRILL, WHICH IS ATTACHED TO THE GEAR INSIDE, IS FROZEN TO THE GEAR WITH CORROSION. - Kirk L. Warner (kwarner) Viewed: 2517 times.
|
06.01.087 - THE SHAFT COMING THROUGH THE LARGE GEAR ON THE LEFT SIDE OF THE HOUSING, WHICH WINDS THE CHAIN UP, IS FROZEN INSIDE OF THE GEAR HOUSING BUSHING. - Kirk L. Warner (kwarner) Viewed: 3764 times.
|
| | | |
| | | |
|
|
|
|
|
ade.thumb[1] - Kirk L. Warner (kwarner) Viewed: 2376 times.
|
06.01.08 - ROD TURNER HAS WELDED UP THE CORRODED AREA OF THE HOUSING AND KIRK WARNER IS STARTING TO GRIND THE WELD FLUSH WITH THE HOUSING SECTION. - Kirk L. Warner (kwarner) Viewed: 2246 times.
|
06.01.08 - ROD TURNER APPLIED HEAT TO THE HOUSING AND SHAFT FOR OVER TWENTY MINUTES IN ORDER TO REMOVE THE SHAFT. - Kirk L. Warner (kwarner) Viewed: 2207 times.
|
06.07.08 - VICTOR HUMPHREYS AND ROD TURNER USE HEAT TO LOOSEN THE NUT HOLDING THE HANDBRAKE WHEEL ONTO THE SHAFT. - Kirk L. Warner (kwarner) Viewed: 2276 times.
|
| | | |
| | | |
|
|
|
|
|
06.07.08 - ROD TURNER HOT RIVETS THE HOUSING OF THE HANDBRAKE TOGETHER. - Kirk L. Warner (kwarner) Viewed: 2326 times.
|
06.07.08 - THE HANDBRAKE BRACKET HAS BEEN PRIMED AND PAINTED, AWAITING THE APPLICATION OF THE REPAIRED HANDBRAKE. - Kirk L. Warner (kwarner) Viewed: 2243 times.
|
06.08.08 - KIRK WARNER HAS PRIMED AND IS PAINTING THE REPAIRED HANDBRAKE. - Kirk L. Warner (kwarner) Viewed: 2281 times.
|
06.08.08 - THE HANDBRAKE HAS BEEN PAINTED AND IS READY FOR APPLICATION TO THE CAR. - Kirk L. Warner (kwarner) Viewed: 2310 times.
|
| | | |
| | | |
|
|
|
|
|
06.18.08 - JOHN FAULHABER TIGHTENS THE NUT SECURING THE HANDWEEL TO THE NEWLY INSTALLED HANDBRAKE. - Kirk L. Warner (kwarner) Viewed: 2302 times.
|
06.18.08 - VICTOR HUMPHREYS AND JOHN FAULHABER INSTALL THE RIVET AND COTTER PIN SECURING THE CHAIN TO THE HANDBRAKE ROD. - Kirk L. Warner (kwarner) Viewed: 2245 times.
|
06.18.08 - THE BELLCRANK IS BEING ATTACHED TO THE HANDBRAKE ROD. - Kirk L. Warner (kwarner) Viewed: 2299 times.
|
06.18.08 - THE HANDBRAKE IS TESTED FOR PROPER FUNTION PRIOR TO FINAL PAINTING. THE CAR IS NOW READY FOR SERVICE. - Kirk L. Warner (kwarner) Viewed: 2257 times.
|
| | | |
| | | |
|
|
|
|
|
06.29.08 - THE AIRBRAKE SYSTEM WAS TESTED. APPLICATION WAS PROPER; HOWEVER, IT DID NOT RELEASE PROPERLY. - Kirk L. Warner (kwarner) Viewed: 2380 times.
|
06.29.08 - WES LLOYD REMOVED THE SERVICE PORTION OF THE AB SYSTEM AND REPLACED IT WITH A REBUILT PORTION. IT STILL DID NOT RELEASE PROPERLY. - Kirk L. Warner (kwarner) Viewed: 2254 times.
|
06.29.08 - KIRK WARNER REMOVED, CLEANED AND REPLACED THE DIRT COLLECTOR. IT WAS FULL OF BUG REMNANTS. - Kirk L. Warner (kwarner) Viewed: 2211 times.
|
06.29.08 - WES LLOYD NOTICED THAT THE NIPPLE TO THE RETAINER VALVE WAS BROKEN. NO AIR WAS LEAKING FROM THE BROKEN NIPPLE. WHEN THE NIPPLE AND THE STREET ELL TO THE RETAINER WERE REMOVED, THEY WERE PLUGGED BY MUD DAUBBER NESTS. WHEN THE BROKEN PIECES WERE REPLACED, THE BRAKES WORKED PROPERLY. THE LAST TIME THE CAR WAS RUN, THERE WAS AN AIR LEAK AND THE CAR WAS BAD ORDERED. THE WASP NESTS, BUILT AFTER THE BREAK OCCURRED, HID THE DEFECT. - Kirk L. Warner (kwarner) Viewed: 2303 times.
|
| | | |
1
